Experimental Study on Variable Mass Negative Stiffness Dynamic Vibration Absorbers

Abstract

Abstract: Aiming at the defects of narrow band of traditional dynamic vibration absorbers, a new type of variable mass negative stiffness dynamic vibration absorber was presented, so that the vibration absorber might have a good low-frequency efficiency. Firstly, the dynamic equation of the variable mass negative stiffness vibration absorber was established and the operating principles of the absorber were analyzed. Secondly, the variable mass negative stiffness vibration absorber experimental table was built, while the PID control program was compiled. The performance of the new dynamic vibration absorbers in vibration reduction on a primary system was studied via dynamic simulation and some experiments. The results show that, the designed vibration absorbers may be continuously adjusted and the effective frequency band of the designed vibration absorbers were widened by 17.3% compared with the traditional vibration absorbers.

Key words: variable mass, dynamic vibration absorber, negative stiffness, PID control

摘要： 针对传统动力吸振器“窄带”缺陷，设计了一种新型的变质量-负刚度动力吸振器，从而可以使吸振器具有较好的低频有效性。建立变质量-负刚度动力吸振器的动力学方程并分析了吸振器的工作原理；搭建了变质量-负刚度动力吸振器试验台，编制了PID控制程序；对吸振器减振性能进行了动力学仿真和试验研究。研究结果表明，所设计的吸振器连续可调，有效频带比传统吸振器频带宽了17.3%。

关键词: 变质量, 动力吸振, 负刚度, PID控制

CLC Number:

TP273

LIU Gang;ZHENG Dasheng;DING Zhiyu;YAO Hongliang. Experimental Study on Variable Mass Negative Stiffness Dynamic Vibration Absorbers[J]. China Mechanical Engineering.

刘刚;郑大胜;丁志雨;姚红良. 变质量-负刚度动力吸振器试验研究[J]. 中国机械工程.

References

[1]KELA L, VAHAOJA P. Recent Studies of Adaptive Tuned Vibration Absorbers/Neutralizers [J]. Appl. Mech. Rev., 2009, 62,0608016.
[2]LIAO G J, GONG X L, KANG C J, et al. The Design of an Active-adaptive Tuned Vibration Absorber Based on Magnetorheological Elastomer and Its Vibration Attenuation Performance [J]. Smart Materials & Structures, 2011, 20(7）： 145-151.
[3]KOMATSUZAKI T, IWATA Y. Design of a Real-time Adaptively Tuned Dynamic Vibration Absorber with a Variable Stiffness Property Using Magnetorheological Elastomer [J]. Shock Vibration, 2015, 2015: 1-11.
[4]HIRUNYAPRUK C, BRENNAN M J, MACE B R,et al. A Tunable Magneto-rheological Fluid-filled Beam-like Vibration Absorber [J]. Smart Materials & Structures, 2010, 19(5): 055020.
[5]GHORBANI-TANHA A K, RAHIMIAN M, NOORZAD A. A Novel Semiactive Variable Stiffness Device and Its Application in a New Semiactive Tuned Vibration Absorber [J]. Journal of Engineering Mechanics， ASCE, 2011, 137(6): 390-399.
[6]MEGAHED S, ABOUUBAKR A K. Vibration Control of Two Degrees of Freedom System Using Variable Inertia Vibration Absorbers: Modeling and Simulation [J]. J. Sound Vibration, 2010, 329(23): 4841-4865.
[7]赵艳青, 夏晶晶, 高强. 变质量颗粒阻尼吸振器及其宽频减振性能 [J]. 中国机械工程, 2015,26(19): 2571-2574.
ZHAO Yanqing, XIA Jingjing, GAO Qiang.VMTPD and Its Performance of Wide Band Vibration Reduction[J].China Mechanical Engineering, 2015,26(19): 2571-2574.
[8]LEE C, CHEN C. Experimental Application of a Vibration Absorber in Structural Vibration Reduction Using Tunable Fluid Mass Driven by Micropump [J]. J. Sound Vibration, 2015, 348(5/6): 31-40.
[9]WU W, CHEN X, SHAN Y. Analysis and Experiment of a Vibration Isolator Using a Novel Magnetic Spring with Negative Stiffness[J].J. Sound Vibration, 2014, 333(13): 2958-2970.

[1]	HU Junfeng, ZHENG Changhu, CAI Jianyang. Adaptive Motion Tracking Control of a Micro-manipulation Stage [J]. China Mechanical Engineering, 2017, 28(08): 905-911,916.
[2]	Huang Wen, Lian Tianlong, Zhang Xingzhong, Yang Ladao, Gao Qi. Research and Development of an Offline Dynamic Secondary Cooling Control Model for Beam Blank Continuous Casting [J]. China Mechanical Engineering, 2016, 27(12): 1643-1647.
[3]	Shi Zhongquan , Ye Wenhua . Research on LQG Control of Spindle Vibration Based on Voice Coil Motor Actuator [J]. China Mechanical Engineering, 2016, 27(10): 1308-1314.
[4]	Liu Jun, Xie Yi, Lin Beiqing. Comprehensive Control for Multi-axle Vehicle Electronically Controlled Hydraulic Steering Systems [J]. China Mechanical Engineering, 2015, 26(24): 3396-3401,3407.
[5]	Wei Lixin, Wang Liping, Xu Deshu, Lin Peng, Yang Jingming. Applications of Multiple Leaders DMPSO in Hydraulic APC System of Cold Strip Mill [J]. China Mechanical Engineering, 2015, 26(23): 3125-3129.
[6]	Qian Lijun, Hu Weilong, Qiu Lihong, Liu Shaojun. Electronic Hydraulic Steering System and Its PID Controller Applied to Third Axle of Multi-axle Vehicles [J]. China Mechanical Engineering, 2015, 26(22): 3008-3013.
[7]	Zhao Yanqing, Xia Jingjing, Gao Qiang, Song Weizhi, Han Ning. VMTPD and Its Performance of Wideband Vibration Reduction [J]. China Mechanical Engineering, 2015, 26(19): 2571-2574,2580.
[8]	Yang Li, Wang Guozuo, Zou Fenggang, Qin Siji. Modeling and Simulation of Servo-driven BHF Control System [J]. China Mechanical Engineering, 2015, 26(19): 2661-2666.
[9]	Zhao Jingyi1,2;Cheng Fei1,2;Guo Rui1,2;Dai Jianjun3. Research on Electro-hydraulic Synchronization Driving Control for Self-Propelled Transporter Suspension Lifting [J]. China Mechanical Engineering, 2014, 25(7): 972-978.
[10]	Chen Guo, Cheng Xiaoyong, Liu Minghua, Luo Yun, Hou Minli, Zhao Bin. A New Type of Dynamic Vibration Absorber for Pipe System Vibration Suppression [J]. China Mechanical Engineering, 2014, 25(23): 3125-3131.
[11]	Zhou Bing;Lü Xuning;Fan Lu;Zhang Wenchao. Integrated Control of Active Suspension System and Active Roll Stabilizer [J]. China Mechanical Engineering, 2014, 25(14): 1978-1983.
[12]	Wang Bo;Cao Chunping;Xu Xiaoyong;Sun Yu. Research on Multi-motor Synchronization of Salivation Unit Based on Neural Network [J]. China Mechanical Engineering, 2014, 25(1): 46-50.
[13]	Chen Dongning1,2;Zhang Guofeng1,2;Yao Chengyu3;Zhang Ruixing1,2. Bacterial Swarm Foraging Optimization Algorithm and Its Application in Optimization of PID Parameters [J]. China Mechanical Engineering, 2014, 25(1): 59-64.
[14]	BANG Zhi-Hui, MA Guang, ZHOU Hong-Meng, LI Feng-Beng. Study on Design and Compensation Algorithm for High Accuracy Tension Controller [J]. China Mechanical Engineering, 2013, 24(4): 458-462.
[15]	Wang Yanwei;Li Yafei;Huang Zhengdong. Research on Collaborative Optimization Method of Mechanical Parts,Mechanical System and #br# Controller Parameters in Mechatronic Products and Its Applications [J]. China Mechanical Engineering, 2013, 24(21): 2955-2959.