离心风机振动噪声及压力脉动实验研究

摘要/Abstract

摘要： 利用传声器、加速度计、微型精密压力传感器对离心风机噪声、管道振动及压力脉动进行测量分析。结果表明，在风机噪声、管道振动、压力脉动频谱中与叶轮转动相关的离散分量明显，旋转频率分量最大；离散频率处噪声、振动与压力脉动相干函数值在0.5以上，而宽频分量处的相干函数值较小；管道内强烈压力脉动主要在距离风机出口5D(D为管道水力直径)的范围内，强度与参考动压ρv2b/2（ρ为流体密度，v为体积速度）相当；在10D以后，管内流场趋于均匀，压力脉动值约为参考动压的20%;压力脉动频谱中旋转频率分量最为明显，其幅度在风机出口2D~4D附近达到最大，为参考动压的25%左右。

关键词: 离心风机, 压力脉动, 噪声, 振动

Abstract: Microphones, accelerometers, and pressure transducers were used to measure the centrifugal fan noises, pipe vibrations and pressure fluctuations respectively. The results show that in the spectra of the fan noises, pipe vibrations and pressure fluctuations, the discrete frequency components related to the impellor rotations are notable,and the rotational frequency(RF) components are the maximum in general.The coherence of the noises and vibrations with the pressure fluctuations is higher than 0.5 at discrete frequencies, but lower at broadband frequencies. The most intensive pressure fluctuations are within 5D from the fan outlet, where D is the pipe hydraulic diameter, with the strength almost equaling to the reference dynamic pressure ρv2b/2 (ρ as fluid density, vb as bulk velocity). After 10D where the flow became quite uniform, the amplitude of pressure fluctuations is approximately 20% of the reference dynamic pressure. The RF components are the most conspicuous in the pressure fluctuation spectra, and the maximum valute is around 25% of the reference dynamic pressure occurring within 2D~4D from the fan outlets.

Key words: centrifugal fan, pressure fluctuation, noise, vibration

中图分类号:

TH43

蔡建程;鄂世举;蒋永华;焦卫东;王冬云. 离心风机振动噪声及压力脉动实验研究[J]. 中国机械工程.

CAI Jiancheng;E Shiju;JIANG Yonghua;JIAO Weidong;WANG Dongyun. Experimental Study of Vibrations, Noises and Pressure Fluctuations of Centrifugal Fan[J]. China Mechanical Engineering.

参考文献

[1]KANEKO S, NAKAMURA T. Flow-induced Vibrations: Classifications and Lessons from Practical Experiences[M]. London: Elsevier, 2014.
[2]HAYASHI I, KANEKO S. Pressure Pulsations in Piping System Excited by a Centrifugal Turbomachinery Taking the Damping Characteristics into Consideration[J]. Journal of Fluids and Structures, 2014, 45(1): 216-234.
[3]FAHY F,ROSSING T D. Foundations of Engineering Acoustics[J]. Journal of the Acoustical Society of America,2002,111(3):1142.
[4]徐辰, 杨爱玲, 毛义军. 离心风机噪声预测方法的进展与分析[J]. 流体机械, 2011, 39 (7): 35-40.
XU Chen, YANG Ailing, MAO Yijun. Review and Analysis on the Prediction Method of Centrifugal Fan Noise[J]. Fluid Machinery, 2011, 39 (7): 35-40.
[5]JIANG Y, YOSHIMURA S, IMAI R, et al. Quantitative Evaluation of Flow-induced Structural Vibration and Noise in Turbomachinery by Full-scale Weakly Coupled Simulation[J]. Journal of Fluids and Structures, 2007, 23 (4): 531-544.
[6]JAFARZADEH B, HAJARI A, ALISHAHI M M, et al. The Flow Simulation of a Low-specific-speed High-speed Centrifugal Pump[J]. Applied Mathematical Modelling, 2011, 35 (1): 242-249.
[7]张兄文，李国君，李军. 离心泵叶轮内变流量流动特性的数值模拟[J]. 农业机械学报, 2005, 36 (10): 62-65.
ZHANG Xiongwen, LI Guojun, LI Jun. Numerical Simulation of Flow Characteristics in Centrifugal Pump Impellers with Variant Mass Flow[J]. Transactions of the Chinese Society for Agricultural Machinery, 2005, 36 (10): 62-65.
[8]蔡建程, 潘杰, GUZZOMI A, 等. 离心泵隔舌区压力脉动测量与分析[J]. 农业机械学报, 2015, 46 (6): 92-96.
CAI Jiancheng, PAN Jie,GUZZOMI A, et al. Pressure Fluctuations around Volute Tongue of Centrifugal Pump[J]. Transactions of the Chinese Society for Agricultural Machinery, 2015, 46 (6): 92-96.
[9]周佩剑, 王福军, 姚志峰. 旋转失速条件下离心泵叶轮压力脉动特性研究[J]. 农业机械学报, 2015, 46 (10): 56-61.
ZHOU Peijian, WANG Fujun, YAO Zhifeng. Investigation of Pressure Fluctuation in Centrifugal Pump Impeller under Rotating Stall Conditions[J]. Transactions of the Chinese Society for Agricultural Machinery, 2015, 46 (10): 56-61.
[10]KHALIFA A E, Al-QUTUB A M, BEN-MANSOUR R. Study of Pressure Fluctuations and Induced Vibration at Blade-passing Frequencies of a Double Volute Pump[J]. Arabian Journal for Science and Engineering, 2011, 36 (7): 1333-1345.
[11]袁寿其, 司乔瑞, 薛菲, 等. 离心泵蜗壳内部流动诱导噪声的数值计算[J]. 排灌机械工程学报, 2011, 29 (2): 93-98.
YUAN Shouqi, SI Qiaorui, XUE Fei, et al. Numerical Calculation of Internal Flow-induced Noise in Centrifugal Pump Volute[J]. Journal of Drainage and Irrigation Machinery Engineering, 2011, 29 (2): 93-98.
[12]刘厚林, 丁剑, 王勇, 等. 基于大涡模拟的离心泵水动力噪声数值模拟[J]. 机械工程学报, 2013, 49 (18): 177-183.
LIU Houlin, DING Jian, WANG Yong, et al. Numerical Simulation of Hydrodynamic Noise in Centrifugal Pump Based on LES[J]. Journal of Mechanical Engineering, 2013, 49 (18): 177-183.
[13]BODEN H, BOM M. Modelling of Fluid Machines as Sources of Sound in Duct and Pipe Systems[J]. Acta Acustica(Les Ulis), 1995, 3(6): 549-560.
[14]徐斌, 冯全科, 余小玲. 压缩机复杂管路压力脉动及管道振动研究[J]. 核动力工程, 2008, 29 (4): 79-83.
XU Bin, FENG Quanke, YU Xiaoling. Study on Pressure Pulsation and Piping Vibration of Complex Piping of Reciprocating Compressor[J]. Nuclear Power Engineering, 2008, 29 (4): 79-83.
[15]周红, 刘永寿, 岳珠峰. 输流管道压力脉动计算分析[J]. 机械科学与技术, 2011, 30 (9): 1435-1438.
ZHOU Hong, LIU Yongshou, YUE Zhufeng. Calculation Analyze of Pressure Pulsation in Fluid Flowing Pipeline[J]. Mechanical Science and Technology for Aerospace Engineering, 2011, 30 (9): 1435-1438.
[16]CHEONG J S. An Analytical Prediction on the Pump-induced Pressure Pulsation in a Pressurized Water Reactor[J]. Annals of Nuclear Energy, 1999, 27 (15): 1373-1383.