油液特性对柱塞泵流量脉动影响的仿真分析

中国机械工程

油液特性对柱塞泵流量脉动影响的仿真分析

高彦军1;谷立臣2;焦龙飞2

1.陕西交通职业技术学院汽车工程学院，西安，710018
2.西安建筑科技大学机械电子技术研究所，西安，710055

出版日期:2017-06-10 发布日期:2017-06-13
基金资助:
国家自然科学基金资助项目（51675399,51275375）

Effects of Oil Properties on Flow Pulsation of Axial Piston Pumps by Simulation Analysis

GAO Yanjun1;GU Lichen2;JIAO Longfei2

1.Automotive Engineering Institute，Shaanxi College of Communication Technology, Xi'an, 710018
2.Research Institute of Mechanical and Electronic Technologies, Xi'an University of Architecture and Technology, Xi'an，710055

Online:2017-06-10 Published:2017-06-13
Supported by:
National Natural Science Foundation of China (No. 51675399,51275375)

摘要/Abstract

摘要： 为研究油液特性对轴向柱塞泵流量脉动的作用规律，对比分析了油液的压缩性、黏性、含气量和流动状态与柱塞泵流量脉动之间的关系，运用FLUENT流场仿真软件对轴向柱塞泵的运动特性进行模拟。数值仿真结果表明：压缩性对泵源流量脉动的影响最大，油液黏性的影响次之，含气量的影响较小，流动状态的影响最小，以上因素的影响程度占油液特性影响的比例分别为86.8%、9.45%、3.59%、0.16%;油液的黏性对泵容积效率的影响最大，压缩性的影响次之，含气量的影响较小，流动状态的影响最小。模型的准确性得到了实验验证，为开展柱塞泵动力学建模以及机电液系统全局耦合性能仿真分析提供了理论依据。

关键词: 轴向柱塞泵；流量脉动；容积效率, 压缩性；油液黏性；流场仿真

Abstract: In order to study the effects of oil characteristics on flow ripple of the axial piston pumps, the relationship among the oil compressibility, viscosity, gas hole, the flow state and flow pulsation was researched based on the movement characteristics of axial piston pumps using the FLUENT software.The results show that the effects of oil compressibility, viscosity, gas hole and the flow state on the flow pulsation are all existed where the oil compressibility has the biggest effects and the flow state has the smallest effects. And the proportion of effects is as 86.8%,9.45%, 3.59%, and 0.16% respectively. Then the simulation results were validated by experimental tests and the accuracy of the simulation was acceptable. So it provides a theoretical basis for the dynamics modeling of piston pumps and simulation and analysis on the global coupling performance of electrohydraulic systems.

Key words: axial piston pump, flow pulsation, volumetric efficiency, compressibility, oil viscosity, flow field simulation

中图分类号:

高彦军, 谷立臣, 焦龙飞. 油液特性对柱塞泵流量脉动影响的仿真分析[J]. 中国机械工程.

GAO Yanjun, GU Lichen, JIAO Longfei. Effects of Oil Properties on Flow Pulsation of Axial Piston Pumps by Simulation Analysis[J]. China Mechanical Engineering.

参考文献

[1]杨俭,徐兵,杨华勇.液压轴向柱塞泵降噪研究进展[J].中国机械工程,2003,14(7):623-626.
YANG Jian, XU Bing,YANG Huayong. Review of Reduction of Noise for Hydraulic Axial Piston Pump[J].China Mechanical Engineering, 2003,14(7):623-626.

[2]徐兵,李春光,张斌,等.基于虚拟样机的轴向柱塞泵压力脉动特性研究[J].中国机械工程,2010,21(10):1203-1207.
XU Bing, LI Chunguang, ZHANG Bin, et al. Research on Pressure Pulsation Characteristics of Axial Piston Pump Based on Virtual Prototype[J]. China Mechanical Engineering, 2010,21(10):1203-1207.

[3]杨华勇,宋月超,徐兵.复杂工况下柱塞泵流量脉动并行仿真与试验研究[J].中国科学:技术科学,2012,42(12):1463-1471.
YANG Huayong, SONG Yuechao, XU Bing. The Flow Pulsation Parallet Simulation and Experimental Study of Piston Pump under Complex Working Conditions[J]. Scientia Sinica Technologica,2012,42(12):1463-1470.

[4]徐兵,宋月超,杨华勇.柱塞泵斜盘交错角降噪结构优化[J]. 机械工程学报,2013,47(6):1043-1050.
XU Bing, SONG Yuechao, YANG Huayong. Optimization of Swaslrplate Cross Angle Noise-reduction Structure for Swash-plate-type Axial Piston Pump[J]. Chinese Journal of Mechanical Engineering,2013,47(6):1043-1050.

[5]MANRING N D. Valve-plate Design for an Axial Piston Pump Operating at Low Displacements[J]. Journal of Dynamic Systems, Measurement and Control,2003,125(1):200-205.

[6]BERGADA J M, KUMAR S, DAVIES D L, et al. A Complete Analysis of Axial Piston Pump Leakage and Output Flow Ripples[J].Applied Mathematical Modelling,2012,36(4):1731-1751.

[7]马吉恩,徐兵,杨华勇,等.轴向柱塞泵流动特性理论建模与实验分析[J].农业机械学报,2010,41(1):188-194.
Ma Jien, XU Bing,YANG Huayong, et al.Modelling and Experiment Study on Fluid Character of Axial Piston Pump[J]. Transactions of the Chinese Society for Agricultural Machinery,2010,41(1):188-194.

[8]WEI X Y, WANG H Y. The Influence of Cross Angle on the Flow Ripple of Axial Piston Pumps by CFD Simulation[J]. Advances in Manufacturing Technology,2012,220/223(13): 1675-1678.

[9]KIM S, MURRENHOFF H. Measurement of Effective Bulk Modulus for Hydraulic Oil at Low Pressure[J].Journal of Fluids Engineering,2012,134(2):21201-21210.

[10]XU Bing, SONG Yuechao,YANG Huayong. Investigation of Test Principle of Flow Ripple Generated by Piston Pump with Complicated Pipe[J].Journal of Mechanical Engineering,2012,48(22):162-167.

[11]SONG Yuechao, XU Bing, YANG Huayong, et al. Modified Practical Approximate Method for Testing Source Flow of Piston Pump[J].Journal of Zhejiang University (Engineering Science), 2014,48(2):200-205.

[12]XU Bing, HU M, ZHANG J H, et al. Impact of Typical Steady-state Conditions and Transient Conditions on Flow Ripple and Its Test Accuracy for Axial Piston Pump[J]. Journal of Mechanical Engineering, 2015,25(8):1012-1022.

[13]徐兵,宋月超,杨华勇.复杂出口管道柱塞泵流量脉动测试原理[J].机械工程学报,2012,48(12):162-167.
XU Bing, SONG Yuechao, YANG Huayong. Investigation of Test Principle of Flow Ripple Generated by Piston Pump with Complicated Pipe[J].Chinese Journal of Mechanical Engineering, 2012,48(12):162-167.

[14]薄纪康,吴小锋.柱塞泵机液动态耦合仿真与实验研究[J].中国机械工程,2014,25(3):410-416.
BO Jikang, WU Xiaofeng. Simulation and Experimental Research on Mechanical-hydraulic Coupling of Piston Pump[J]. China Mechanical Engineering,2014,25(3):410-416.