中国机械工程 ›› 2010, Vol. 21 ›› Issue (11): 1301-1305.

• 机械基础工程 • 上一篇    下一篇

一种新型2R完全解耦并联机构的运动学和奇异性分析
 

范彩霞1,2;刘宏昭1;张彦斌3;袁格侠1,4
  

  1. 1.西安理工大学,西安,710048
    2.焦作大学,焦作,454000
    3.河南科技大学,洛阳,471003
    4.宝鸡文理学院,宝鸡,721007
  • 出版日期:2010-06-11 发布日期:2010-06-23
  • 基金资助:
    国家自然科学基金资助项目(50575180);陕西省重点学科建设专项基金资助项目;西安理工大学优秀博士学位论文研究基金资助项目(102-210911)
    National Natural Science Foundation of China(No. 50575180)

Kinematics and Singularity Analysis of a Novel 2R Fully-decoupled Parallel Manipulator

Fan Caixia1,2;Liu Hongzhao1;Zhang Yanbin3;Yuan Gexia1,4   

  1. 1.Xi’an University of Technology,Xi’an,710048
    2.Jiaozuo University,Jiaozuo,Henan,454000
    3.Henan University of Science and Technology,Luoyang,Henan,471003
    4.Baoji University of Arts and Sciences,Baoji,Shanxi,721007
  • Online:2010-06-11 Published:2010-06-23
  • Supported by:
    National Natural Science Foundation of China(No. 50575180)

摘要:

提出了一种完全解耦的二维转动并联机构。基于自由度特征矩阵分析了机构运动类型,运用单开链法确定了机构的自由度和主动副,同时求解了机构的位置和速度,并根据正逆雅可比矩阵系统分析了机构的奇异位形。由于该机构的全局雅可比矩阵为三角阵,该机构的运动完全解耦,因此可以简化机器人轨迹规划和控制。

 

关键词:

Abstract:

This paper presented a novel two degree-of-freedom (DOF) fully-decoupled parallel mechanism(PM) with two dimensional rotation. First,based on the DOF feature matrix kinematic type was analyzed, and using single open-chain theory the calculation of the DOF of the mechanism and selection of the actuated pairs were performed. Next, the displacement and velocity of the mechanism were analyzed,and according to the direct and the inverse Jacobian matrices of the manipulator singularity conditions were discussed systematically. At last the motion of the mechanism was fully decoupled for the Jacobian matrix being a triangular matrix,which can simplify control and trajectory planning of the mechanism.

Key words: parallel mechanism, fully-decoupled, kinematics analysis, singularity analysis

中图分类号: