永磁轴承最小悬浮转速与转动惯量的关系研究

摘要/Abstract

摘要：

为研究永磁悬浮旋转体实现稳定平衡的最小转速与转动惯量的关系,设计了一种新型永磁轴承透平机,在同一定子内安装3个结构和尺寸相同但转动惯量不同的转子。测量3个转子的转动惯量，并用均匀分布在透平机定子外部的4个霍尔传感器测量转子偏心距。
实验结果表明，当转速超过某一临界值时,陀螺效应使得永磁悬浮透平机转子维持稳定的悬浮，并且最小悬浮转速与转动惯量负相关,即转动惯量越大的转子悬浮需要的转速越小。

关键词: 永磁悬浮轴承, 转子偏心距, 最小悬浮转速, 转动惯量

Abstract:

To analyze the relations between the minimal speed of permanent maglev rotator with its rotating inertia,one novel permanent maglev turbine model was designed:one stator and three rotors which had the same size but different rotational inertias.The three rotors' rotational inertias were measured,
and four Hall sensors distributed evenly at the turbine's stator were used to
measure the rotor's eccentricity.The results demonstrate that the rotors of the permanent maglev turbine can maintain stable suspension by gyroscopic effect when the
speed is higher than a critical point.And the minimal speed for suspension has a negative correlation with the rotor's rotational inertia,namely,the bigger the inertia of the
rotor,the smaller the required speed for suspension.

Key words: permanent magnetic bearing(PMB), rotor eccentricity, minimal speed for suspension, rotational inertia

中图分类号:

TH133.3

许自豪, 钱坤喜, 王颢. 永磁轴承最小悬浮转速与转动惯量的关系研究[J]. 中国机械工程, 2012, 23(8): 900-905.

HU Zi-Hao, JIAN Kun-Chi, WANG Hao. Relations between Novel PMB's Minimal Speed for Suspension and Its Inertia[J]. China Mechanical Engineering, 2012, 23(8): 900-905.

参考文献

[1]刘淑琴[1],边忠国[1],李红伟[1],关勇[1].磁悬浮轴承人工心脏泵的研究[J].中国科技成果,2009(4):14-16.
[2]Hideo H,Tadahiko S,Setsuo T. Third--generation Blood Pumps with Mechanical Noncontact Magnetic Bearings[J].Artificial Organs,2006,(05):324-338.
[3]刘晓军[1],刘小英[1],胡业发[2],骆清铭[1].人工心脏泵磁悬浮转子质量不平衡及磁耦合研究[J].中国机械工程,2006,17(16):1651-1655.
[4]杨晟[1],刘淑琴[1],关勇[1].轴流式磁悬浮人工心脏泵驱动电机的研究[J].中国机械工程,2010(8):893-896.
[5]Jahanmir S,Hunsberger A Z,Heshmat H. Performance Characterization of a Rotary Centrifu-gal Left Ventricular Assist Device with Magnetic Suspension[J].Artificial Organs,2008,(05):366-375.
[6]Kataoka H,Kimura Y,Fujita H. Influence of Radial Clearance and Rotor Motion to Hemolysis in a Journal Bearing of a Centrifugal Blood Pump[J].Ar tifieial Organs,2006,(11):841-854.
[7]郭龙辉(综述)[1],张杰民[1],刘晓程(审校)[1].第三代血泵的研究进展[J].中国胸心血管外科临床杂志,2010(4):321-325.
[8]Earnshaw S. On the Nature of the Molecular Forces which Regulate the Constitution of the Luminiferous Ether[J].Transactions of the Cambridge Philosophical Society,1842.97-112.
[9]Braunbeck W. Freischwebende Koerper im Elektrischen und Magnetischen Feld[J].Zeitschrift für Physik,1939.764-769.
[10]Geim A K,Simon M D,Boamfa M I. Magnet Levitation at Your Fingertips[J].Nature,1999,(6742):323-323.doi:10.1038/22444.
[11]Harrigan R M. Levitation Device[P].U.S.4382245,1983.
[12]Simon M D,H eflinger L O,Ridgway S L. Spin Sta-bilized Magnetic Levitation[J].American Journal of Physiology,1997.286-292.
[13]Qian K X,Zeng P,Ru W M. New Concepts and New Design of Permanent Maglev Rotary Ar-tificial Heart Blood Pumps[J].Medical Engineer-ing and Physics,2006,(04):383-388.
[14]Qian K X,Wan F K,Ru W M. Study on Sta-ble Equilibrium of Levitated Impeller in Rotary Pump with Passive Magnetic Bearings[J].Journal of Medical Engineering and Technology,2006,(02):78-82.
[15]Qian K X;Xu H X.Gyro--effect and Earnshaw's Theorem:Stable and Unstable Equilibrium for Ro-tary and Stationary Permanent Magnetic Levitators[A]上海,20081323-1325.
[16]Qian K X. Novel Magnetic Spring and Magnetic Bearing[J].IEEE Transactions on Magnetics,2003,(01):559-561.doi:10.1109/TMAG.2002.806524.