燃气轮机齿轮耦合转子系统动力学特性分析

中国机械工程 ›› 2010, Vol. 21 ›› Issue (14): 1655-1660.

燃气轮机齿轮耦合转子系统动力学特性分析

李国云1,2;秦大同2

1.攀枝花学院,攀枝花,617000

2.重庆大学机械传动国家重点实验室,重庆,400044

出版日期:2010-07-27 发布日期:2010-09-19
基金资助:
国家科技支撑计划资助项目(2006BAF01B07)
The National Key Technology R&D Program（No. 2006BAF01B07）

Research on Dynamic Characteristics of Gear Coupling Rotor System in Gas Turbine

Li Guoyun1,2;Qin Datong2

1.Panzhihua University,Panzhihua,Sichuan,617000

2.State Key Lab of Mechanical Transmission of Chongqing University,Chongqing,400044

Online:2010-07-27 Published:2010-09-19
Supported by:
The National Key Technology R&D Program（No. 2006BAF01B07）

摘要/Abstract

摘要：

为了降低燃气轮机齿轮转子系统不平衡响应,采用了耦合转子动力学方法对系统进行分析评价,在考虑齿轮啮合及轴承动力特性系数的基础上,利用传递矩阵法分别建立了两单轴转子的弯曲振动分析模型,推导了人字齿轮耦合单元的传递矩阵,应用整体传递矩阵建立了人字齿轮转子系统的弯扭耦合振动分析模型,对某燃气轮机齿轮-转子-轴承系统进行了振动特性分析。通过数值计算与分析,获得单轴转子以及齿轮耦合转子的不平衡响应。研究结果表明,该齿轮耦合使转子系统不平衡响应增大,同时传动系统的工作转速远离临界转速,系统处于安全稳定状态。

关键词:

转子, 弯扭耦合, 不平衡响应, 人字齿轮, 传递矩阵法, 动力学特性

Abstract:

In order to reduce the unbalance reponse of gear-rotor system of gas turbine,a dynamic analysis method was applied to evaluate this system.Based on dynamic parameters of journal bearing and gears, the lateral vibration analysis model of only one rotor was built by means of the transfer matrix method. The transmission matrix of herringbone gear-coupled unit was derived. In addition, using whole transfer matrix method, the lateral-torsional coupling analysis model of herringbone gear-rotor system was set up, and the vibration characteristics of gear-rotor-bearing system of gas turbine was

analyzed.Through numerical calculations and analyses,the eigenvalue of gear-rotor

system,the Logarithmic decrement and the critical speed were

obtained.The results show that the operational speed of this gear-rotor-bearing system is far away from the critical speed. This tranasmissiion system is stable and safe.

Key words: rotor, bending-torsional coupling, unbalance, herringbone gear, transfer matrix method, dynamic characteristics

中图分类号:

TH113

李国云, 秦大同.

燃气轮机齿轮耦合转子系统动力学特性分析

[J]. 中国机械工程, 2010, 21(14): 1655-1660.

LI Guo-Yun, QIN Da-Tong.

Research on Dynamic Characteristics of Gear Coupling Rotor System in Gas Turbine

[J]. China Mechanical Engineering, 2010, 21(14): 1655-1660.

参考文献

[1]闻邦椿顾家柳.高等转子动力学--理论、技术与应用[M].北京:机械工业出版社,1998..
[2]Fan Y S, Wan Q S M. Dynamic Characteristics of the Coupled System of the High Pressure Rotor and the Radial Driveshaft of a Turbofan Engine[J]. Advanced Materials Research, 2008,44/46 : 127-134.
[3]Hsieh S C,Chen J H,Lee A C. A Modified Transfer Matrix Method for the Coupled Lateral and Torsional Vibrations of Symmetric Rotor--bearing Systems[J]. Journal of Sound and Vibration, 2006,289 (1/2) :294-333.
[4]Hsieh S C,Chen J H,Lee A C. A Modified Transler Matrix Method for the Coupled Lateral and Torsional Vibrations of Asymmetric Rotor-bearing Systems[J]. Journal of Sound and Vibration, 2008, 312(4/5):563-571.
[5]Lee A S, Ha J W. Prediction of Maximum Unbalance Responses of a Gear--coupled Two Shaft Ro tot--bearing System[J]. Journal of Sound and Vibration,2005,283(3/5) :507-523.
[6]Zhang Z, Du D M, He Q. Response Calculation and Analyses of Torsional Cibration of Turbine--generator Shafts[C]//Ameriean Society of Mechanical Engineers (ASME) Power Conference. Atlanta, 2006:2-4.
[7]庞辉[1],方宗德[1],欧卫林[2].多平行齿轮耦合转子系统的振动特性分析[J].振动与冲击,2007,26(6):21-25.
[8]Maharathi B B. Dynamic Behaviour Analysis of Linear Rotor- bearing Systems Using the Complex Transfer Matrix Technique[J]. International Journal of Acoustics and Vibrations, 2005,10(3) : 413-417.
[9]宋雪萍[1],于涛[1],李国平[1],闻邦椿[1].齿轮轴系弯扭耦合振动特性[J].东北大学学报：自然科学版,2005,26(10):990-993.
[10]Jun O S, Gadala M S. Dynamic Behavior Analysis of Cracked Rotor[J]. Journal of Sound and Vibration, 2008,309 (1/2) : 210-245.
[11]Su J C T, Lie K N, Rotor Dynamic Instability Analysis on Hybrid Air Journal Bearings[J]. Tribology International, 2006,39 (3) : 238-248.
[12]宋雪萍[1],刘树英[1],闻邦椿[1].齿轮-转子系统的振动特性分析[J].机械科学与技术,2006,25(2):153-157.
[13]苏武会[1],李育锡[1].斜齿轮转子系统弯扭耦合振动分析的整体传递矩阵法[J].机床与液压,2007,35(6):38-40.
[14]柴山 [1],高连勇 [2].多转子系统弯扭耦合振动分析的整体传递矩阵法[J].机械设计,2005,22(10):8-10.
[15]欧卫林[1],王三民[1],袁茹[1].齿轮耦合复杂转子系统弯扭耦合振动分析的轴单元法[J].航空动力学报,2005,20(3):434-439.