Research on Differential Steering Mechanism Based on Tire Cornering

doi:10.3969/j.issn.1004-132X.2025.10.008

China Mechanical Engineering ›› 2025, Vol. 36 ›› Issue (10): 2224-2231.DOI: 10.3969/j.issn.1004-132X.2025.10.008

Previous Articles Next Articles

Research on Differential Steering Mechanism Based on Tire Cornering

Biaofei SHI¹^,²(), Xiaoming YE³, Haoyu LYU¹^,², Feng LAI³

^1.School of Vehicle and Mobility，Tsinghua University，Beijing，100084
^2.State Key Laboratory of Intelligent Green Vehicle and Mobility，Tsinghua University，Beijing，100084
^3.Research&Development Institute，Dongfeng Motor Corporation，Wuhan，430058

Received:2024-10-28 Online:2025-10-25 Published:2025-11-05
Contact: Biaofei SHI

基于轮胎侧偏的差动转向机理研究

史彪飞¹^,²(), 叶晓明³, 吕皓玉¹^,², 赖锋³

^1.清华大学车辆与运载学院, 北京, 100084
^2.清华大学智能绿色车辆与交通全国重点实验室, 北京, 100084
^3.东风汽车集团有限公司研发总院, 武汉, 430058

通讯作者: 史彪飞
作者简介:史彪飞^*（通信作者），男，1993年生，助理研究员、博士后研究人员。研究方向为汽车线控底盘、汽车动力学与控制。E-mail：1935792849@qq.com。
第一联系人：洪睿，女，1997年生，硕士研究生。研究方向为流体力学。E-mail： ah.hongrui@qq.com。胡建军^*（通信作者），男，1982年生，教授、博士研究生导师。研究方向为流体力学。E-mail： kewei729@163.com
基金资助:
山东省重点研发计划(2023CXGC010214);芜湖市“赤铸之光”重大科技成果工程化项目(2023zc02)

Abstract

Abstract:

Differential steering based on tire cornering suited low-speed， large steering radius scenarios of distributed drive electric vehicles（DDEV） without steering mechanisms. In order to study the mechanism of differential steering based on tire cornering， a 7-degree-of-freedom DDEV dynamic model with no steering mechanism and PAC2002 tire model were established. Then， the formation mechanism of differential steering was analyzed and a systematic analysis method from the input of differential longitudinal force to the output of vehicle steering radius of differential steering was proposed by considering the tire force longitudinal-lateral-coupling characteristics. Leveraging the proposed systematic analysis method， the stability of differential steering and the influences of differential longitudinal force， vehicle parameters and tire characteristics on steering radius were studied. Finally， a Carsim/Simulink joint simulation platform was established to simulate differential steering under different influencing factors. The results show that within the range of tire cornering， the larger the differential longitudinal force， the larger the ratio of track width to wheelbase， and the smaller the tire lateral stiffness， the smaller the steering radius.

Key words: distributed drive electric vehicle（DDEV）, differential steering, tire cornering, steering radius

摘要：

基于轮胎侧偏的差动转向适合于无转向机构分布式驱动车辆的低速、大转向半径场景，为深入研究该差动转向的机理，建立了7自由度无转向机构分布式驱动电动汽车整车模型及PAC2002轮胎模型，分析了差动转向的形成机理并结合轮胎纵侧耦合特性提出一种从差动纵向力输入到汽车转向半径输出的差动转向系统性分析方法，并基于此方法研究了差动转向稳定性及差动纵向力、车辆结构参数、轮胎特性等对转向半径的影响特性。最后建立了Carsim/Simulink联合仿真平台，进行不同影响因素下的差动转向仿真。研究结果表明，在轮胎侧偏范围内，差动纵向力越大、轮距与轴距之比越大、轮胎侧偏刚度越小，则所产生的汽车转向半径越小。

关键词: 分布式驱动电动汽车, 差动转向, 轮胎侧偏, 转向半径

CLC Number:

U461

Biaofei SHI, Xiaoming YE, Haoyu LYU, Feng LAI. Research on Differential Steering Mechanism Based on Tire Cornering[J]. China Mechanical Engineering, 2025, 36(10): 2224-2231.

史彪飞, 叶晓明, 吕皓玉, 赖锋. 基于轮胎侧偏的差动转向机理研究[J]. 中国机械工程, 2025, 36(10): 2224-2231.

Figures/Tables 2

References 14

[1]	PASHA J， LI B， ELMI Z， et al. Electric Vehicle Scheduling：State of the Art， Critical Challenges， and Future Research Opportunities［J］. Journal of Industrial Information Integration， 2024， 38：100561.
[2]	ZHANG Z， YU J， HUANG C， et al. Coordinated Torque Distribution Method of Distributed Drive Electric Vehicle to Reduce Control Intervention Sense［J］. Vehicle System Dynamics， 2024， 62（1）：198-221.
[3]	WANG J， WANG X， LUO Z， et al. Active Disturbance Rejection Control of Differential Drive Assist Steering for Electric Vehicles［J］. Energies， 2020， 13（10）：2647.
[4]	HU J， HU Y， LU C， et al. Integrated Path Planning for Unmanned Differential Steering Vehicles in Off-road Environment with 3D Terrains and Obstacles［J］. IEEE Transactions on Intelligent Transportation Systems， 2021， 23（6）：5562-5572.
[5]	CHEN T， CAI Y， CHEN L， et al. Trajectory Tracking Control of Steer-by-wire Autonomous Ground Vehicle Considering the Complete Failure of Vehicle Steering Motor［J］. Simulation Modelling Practice and Theory， 2021， 109：102235.
[6]	KOZLOWSKI K， PAZDERSKI D. Modeling and Control of a 4-wheel Skid-steering Mobile Robot［J］. International Journal of Applied Mathematics and Computer Science， 2004， 14（4）：477-496.
[7]	WONG J Y， CHIANG C F. A General Theory for Skid Steering of Tracked Vehicles on Firm Ground［J］. Proceedings of the Institution of Mechanical Engineers， Part D：Journal of Automobile Engineering， 2001， 215（3）：343-355.
[8]	李春明，盖江涛，曾根，等．机电复合传动履带车辆中心转向控制策略［J］．装甲兵学报，2022，1（1）：71-77.
	LI Chunming， GAI Jiangtao， ZENG Gen， et al. Pivot Steering Control Strategy of EMT for Tracked Vehicles［J］. Journal of Armored Forces， 2022，1（1）：71-77.
[9]	徐涛，申焱华，张文明，等. 分布驱动轮式车辆差动转向动力学特性研究［J］. 汽车工程， 2018， 40（7）：812-819.
	XU Tao， SHEN Yanhua， ZHANG Wenming. A Study on Dynamic Characteristics of Differential Steering in Distributed-drive Wheeled Vehicles ［J］. Automotive Engineering， 2018， 40（7）：812-819.
[10]	宋健，赵文宗，戴亚奇，等. 基于轮胎侧偏的差动转向及控制［J］. 清华大学学报（自然科学版）， 2020， 60（2）：117-123.
	SONG Jian， ZHAO Wenzong， DAI Yaqi. Control of a Tire-cornering Based Differential Steering System［J］. Journal of Tsinghua University（Science and Technology）， 2020， 60（2）：117-123.
[11]	SHAJU A， KUMAR P A. Modelling Transient Response Using PAC 2002-based Tyre Model［J］. Vehicle System Dynamics， 2022， 60（1）：20-46.
[12]	余志生. 汽车理论［M］. 第5版．北京：机械工业出版社.
	YU Zhisheng. Automotive Theory［M］. 5th. Beijing：China Machine Press.
[13]	GUO N， LENZO B， ZHANG X， et al. A Real-time Nonlinear Model Predictive Controller for Yaw Motion Optimization of Distributed Drive Electric Vehicles［J］. IEEE Transactions on Vehicular Technology， 2020， 69（5）：4935-4946.
[14]	WANG H， GUO B. Carsim-based Modelling and Analysis of Exit Ramp Safety［J］. American Journal of Traffic and Transportation Engineering， 2023， 8（3）：69-75.

参数	数值	参数	数值
整车质量	2730 kg	轴距	2.81 m
轮距	1.62 m	质心高度	0.74 m
质心到前轴距离	1.529 m	车轮滚动半径	0.385 m
质心到后轴距离	1.281 m

参数	数值	参数	数值
整车质量	2730 kg	轴距	2.81 m
轮距	1.62 m	质心高度	0.74 m
质心到前轴距离	1.529 m	车轮滚动半径	0.385 m
质心到后轴距离	1.281 m

项目	数值
目标附加横摆力矩/（kN·m）	3	6	9
差动纵向力/N	926	1852	2778
四轮侧向力绝对值平均值/N	536	1077	1619
四轮侧偏角绝对值平均值/（°）	0.29	0.58	0.91
转向半径/m	239	121	79

项目	数值
目标附加横摆力矩/（kN·m）	3	6	9
差动纵向力/N	926	1852	2778
四轮侧向力绝对值平均值/N	536	1077	1619
四轮侧偏角绝对值平均值/（°）	0.29	0.58	0.91
转向半径/m	239	121	79

Research on Differential Steering Mechanism Based on Tire Cornering

基于轮胎侧偏的差动转向机理研究

RichHTML

PDF

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 2

References 14

Related Articles 6

Recommended Articles

Metrics

[1]	CHAI Tian, LI Fan, LEI Fei, LIU Jie, ZENG Xia , TANG Yingshi, . Study on Steering Geometry of Racing Cars with Consideration of Tire Cornering Characteristics [J]. China Mechanical Engineering, 2017, 28(09): 1106-1111.
[2]	Mao Zhiwei, Wu Xun, Zhou Shaoling, Li Xiangchun, Deng Fanling. Kinematics Analysis and Simulation for Four Wheel Drive All Wheel Differential Steering Mobile Welding Robots [J]. China Mechanical Engineering, 2016, 27(13): 1731-1734.
[3]	Zhao Wanzhong, Wang Chunyan, Zhang Zongqiang, Yu Leiyan, Zhao Ting. Study on Road Feel Control of Differential Steering for In-wheel Electric Vehicle [J]. China Mechanical Engineering, 2014, 25(1): 87-91.
[4]	CHANG Wei-Yan-1, QIU Fa-Ju-2, YANG Chao-Zhen-1. Kinematics Analysis of Differential Steering Exploration Robot with Compound Walking Mechanism [J]. China Mechanical Engineering, 2012, 23(2): 166-171.
[5]	DENG Liang, CHEN Bao-Xue, ZHANG Jian-Ban, GU Dong-Chao, SUN Hai-Chao. Dynamic Model on AFS Headlamp Swiveling Angle [J]. China Mechanical Engineering, 2011, 22(7): 864-869.
[6]	MA Lei, DIAO Yun, WANG Lian-Dong, DIAO Meng-Hui, YANG Zhi-An, LI Ning. Sreering Test and Slide-rate Analysis of 4WID EV under Identity-power Pattern [J]. China Mechanical Engineering, 2010, 21(06): 725-728.