基于传递矩阵的汽车多层吸声材料特性研究

中国机械工程 ›› 2014, Vol. 25 ›› Issue (1): 134-137.

基于传递矩阵的汽车多层吸声材料特性研究

刘刚田1,2;吉晓民1

1.西安理工大学，西安，710048
2.河南科技大学，洛阳，471003

出版日期:2014-01-10 发布日期:2014-01-14
基金资助:
国家自然科学基金资助项目(51075124)；河南省科技攻关资助项目(11210221051)

A Study of Characteristics of Automobile Multilayer Sound Absorption Materials Based on Transfer Matrix

Liu Gangtian1,2;Ji Xiaomin1

1.Xi'an University of Technology，Xi'an，710048
2.Henan University of Science & Technology，Luoyang，Henan，471003

Online:2014-01-10 Published:2014-01-14
Supported by:
National Natural Science Foundation of China（No. 51075124）

摘要/Abstract

摘要：

利用传递矩阵对汽车吸声材料的吸声特性进行了分析。首先将多层均匀吸声材料进行布置，得到两层吸声材料之间的声压与介质中质点的振动速度关系。然后将实验材料钢板前面的第i层与第i+1层吸声材料分离开来单独考虑，得到多层吸声材料的吸声系数计算公式。最后对三层不同厚度的均匀吸声材料之间的吸声系数进行了实例计算和实验测量，验证了传递矩阵计算所得的吸声系数是正确的。

关键词: 吸声材料, 传递矩阵, 主动吸声, 吸声系数

Abstract:

This paper analyzed the sound absorption characteristics of automobile sound absorption materials with the transfer matrix. Firstly, the multilayer uniform sound absorption materials were decorated, and the sound pressure and normal particle vibration velocity relationship between two layers of sound materials were obtained. Then the i layer and the i+1 layer of sound absorption materials in front of the experimental material steel plate were considered separately, and the acoustic impedance ratio between two layers was obtained. Thus, the sound absorption coefficient calculation formula of multilayer sound absorption materials would be given. Finally, instances calculation and experimental measurements of the sound absorption coefficient among the uniform sound absorption materials of three different thicknesses were carried out, and the correctness of the sound absorption coefficient was verified, which was studied from the transfer matrix characteristic calculation of automobile multilayer sound absorption materials. A theoretical basis for transfer matrix characteristics of the multilayer sound absorption materials will be provided.

Key words: sound absorption material, transfer matrix, active sound absorption, sound absorption coefficient

中图分类号:

TB53

刘刚田, 吉晓民. 基于传递矩阵的汽车多层吸声材料特性研究[J]. 中国机械工程, 2014, 25(1): 134-137.

Liu Gangtian, Ji Xiaomin. A Study of Characteristics of Automobile Multilayer Sound Absorption Materials Based on Transfer Matrix[J]. China Mechanical Engineering, 2014, 25(1): 134-137.

参考文献

[1]曲巍巍，高峰.基于噪声方差估计的小波阈值降噪研究[J].机械工程学报，2010，46(2)：28-33.
Qu Weiwei，Gao Feng. Study on Wavelet Threshold Denoising Algorithm Based on Estimation of Noise Variance[J]. Chinese Journal of Mechanical Engineering，2010，46(2)：28-33.
[2]Ducourneau J，Planeau V. Measurement of Sound Absorption Coefficient of Flat Surfaces in a Workshop[J]. Applied Acoustics，2009，70：710-721.
[3]Leung R C K，So R M C，Wang M H. In-duct Orifice and Its Effect on Sound Absorption[J]. Journal of Sound and Vibration，2007，299：990-1004.
[4]Chen Zhixin，Xu Jinwu，Yang Debin. New Method of Extracting Weak Failure Information in Gearbox by Complex Wavelet Denoising[J]. Chinese Journal of Mechanical Engineering，2008，21(4)：87-91.
[5]Wang Xinqing，Wang Yaohua，Qian Shuhua，et al. New Technology for Fault Diagnosis Based on Wavelet Denoising and Modified Exponential Time-frequency Distribution[J]. Chinese Journal of Mechanical Engineering，2001，14(3)：262-265.
[6]Orduna F B，Nelson P A. An Adaptive Controller for the Active Absorption of Sound[J]. Journal of the Acoustical Society of America，1992，91：2740-2747.
[7]Lacour O，Gall M A，Thenail D. Preliminary Experiments on Noise Reduction in Cavities Using Active Impedance Changes[J]. Journal Sound and Vibration，1990，230(1)： 69-99.
[8]杨光，王玉丹. 传递矩阵法进行电主轴的动力学特性分析[J]. 机械设计与制造，2001(2)：50-51.
Yang Guang，Wang Yudan. The Dynamic Characteristic Analysis on the Electric Main Shaft Using Transfer Matrix Method[J]. Machinery Design & Manufacture，2001(2)：50-51.
[9]牛宁，朱从云，李力. 穿孔共振消声器的声场传递机理研究[J]. 机械设计与制造，2008(2)：176-177.
Niu Ning，Zhu Congyun，Li Li. The Study of Transmission Matrix of Perforated and Resonance Muffler[J]. Machinery Design & Manufacture，2008(2)：176-177.
[10]赵明，黄其柏，朱从云，等. 穿孔扩张消声结构的声场传递矩阵研究[J]. 噪声与振动控制，2005，25(2)：33-35.
Zhao Ming，Huang Qibai，Zhu Congyun，et al. The Study of Transmission Matrix of Cross-flow Muffler[J]. Noise and Vibration Control，2005，25(2)：33-35.
[11]姜洪源, 武国启. 金属橡胶材料非线性吸声特性研究[J]. 机械工程学报，2010，46(19)：70-77.
Jiang Hongyuan，Wu Guoqi. Nonlinear Sound Absorption Performance of Metal Rubber Material[J].Chinese Journal of Mechanical Engineering，2010，46(19)：70-77.
[12]Jiang Hongyuan，Yan Hui，Ao Hungrui，et al. Calculation of Elastic Damping Characteristics of Rotor Support Made of Metal Rubber Material under Variable Loads[J]. Chinese Journal of Mechanical Engineering，2007，20(6)：33-37.
[13]朱从云. 主动吸声降噪理论与方法研究[D].武汉：华中科技大学，2005.