柔性空间机械臂系统的双环积分滑模控制

中国机械工程 ›› 2011, Vol. 22 ›› Issue (16): 1906-1912.

柔性空间机械臂系统的双环积分滑模控制

梁捷;陈力

福州大学，福州，350108

出版日期:2011-08-25 发布日期:2011-08-30
基金资助:
国家自然科学基金资助项目(11072061，10672040)；福建省自然科学基金资助项目(2010J01003)
National Natural Science Foundation of China（No. 11072061，10672040）;
Fujian Provincial Natural Science Foundation of China（No. 2010J01003）

Dual-loop Integral Sliding Mode Control for Flexible Space Manipulator

Liang Jie;Chen Li

Fuzhou University,Fuzhou,350108

Online:2011-08-25 Published:2011-08-30
Supported by:

National Natural Science Foundation of China（No. 11072061，10672040）;
Fujian Provincial Natural Science Foundation of China（No. 2010J01003）

摘要/Abstract

摘要：

讨论了载体位置不受控、姿态受控的情况下，漂浮基柔性空间机械臂关节运动及柔性振动主动抑制的控制问题。由系统动量守恒关系及假设模态法，利用拉格朗日方法建立了柔性空间机械臂的系统动力学方程，之后采用奇异摄动理论，将其分解为表示刚性运动的慢变子系统和柔性振动的快变子系统。以此为基础，针对慢变子系统——柔性空间机械臂的刚性运动，设计了系统参数未知情况下的双环积分滑模控制方案，以控制柔性空间机械臂的载体姿态及机械臂关节铰协调地完成各自在关节空间的期望运动;而对于快变子系统——柔性臂的振动，则设计了分级模糊控制方案来主动抑制柔性杆的振动。计算机数值仿真证实了该方法的可靠性和有效性。

关键词:

漂浮基, 柔性空间机械臂, 奇异摄动理论, 双环积分滑模控制, 分级模糊控制

Abstract:

This paper discussed the trajectory tracking and vibration suppression control problems of free-floating flexible space manipulator with an attitude controlled base. With the law of conservation of momentum, the Lagrangian principle was utilized to model the dynamics function of the flexible space manipulator incorporating the assumed modes method. Using singular perturbation theory, a slow subsystem describing the rigid motion and a fast subsystem corresponding to the flexible motion were obtained. Then, a composite controller for coordinated motion between the base's attitude and the manipulator's joints of flexible space manipulator system was designed. The slow-subsystem dual-loop integral sliding mode controller dominated the trajectory tracking of coordinated motion in the presence of unknown parameters. The fast-subsystem controller damped out the vibration of the flexible link by hierarchical fuzzy logic controller. Numerical simulation results illustrate that the proposed controller is reliable and effective.

Key words: free-floating, flexible space manipulator, singular perturbation theory, dual-loop integral sliding mode control, hierarchical fuzzy logic control

中图分类号:

TP241

梁捷, 陈力.

柔性空间机械臂系统的双环积分滑模控制

[J]. 中国机械工程, 2011, 22(16): 1906-1912.

LIANG Cha, CHEN Li.

Dual-loop Integral Sliding Mode Control for Flexible Space Manipulator

[J]. China Mechanical Engineering, 2011, 22(16): 1906-1912.

参考文献

[1]Lindsay E. Canadian Space Robotics on Board the International Space Station [C]//2005 CCToMM Symposium on Mechanisms, Machines, and Mechatronics. Montreal: Canadian Space Agency, 2005:26-27.
[2]Abiko S, Hirzinger G. Adaptive Control for a Torque Controlled Free- Floating Space Robot with Kinematic and Dynamic Model Uncertainty [C]//Proceedings of the 2009 IEEE/RSJ International Conference on Intelligent Robots and Systems. St. Louis,MO:IEEE, 2009:2359-2364.
[3]刘延柱.航天器姿态动力学[M].北京：国防工业出版社,1995.
[4]丁希仑,战强,解玉文.自由漂浮的空间机器人系统的动力学奇异特性分析及其运动规划[J].航空学报,2001,22(5):474-477.
[5]戈新生[1],陈立群[2],刘延柱[3].一类多体系统的非完整运动规划最优控制[J].工程力学,2006,23(3):63-68.
[6]王从庆[1],石宗坤[1],袁华[1].自由浮动空间双臂机器人的鲁棒协调控制[J].宇航学报:436-440.
[7]梁捷[1],陈力[1].双臂空间机器人基于高斯型函数的姿态、关节运动模糊自适应补偿控制[J].中国机械工程,2010(3):330-336.
[8]Murotsu Y, Tsujio S, Senda K. Trajectory Control of Flexible Manipulators on a Free- flying Space Robot[J].IEEE Control Systems, 1992, 12(3) :51-57.
[9]洪在地[1],贠超[1],陈力[2].柔性臂漂浮基空间机器人建模与轨迹跟踪控制[J].机器人,2007,29(1):92-96.
[10]戈新生[1],刘延柱[2].空间刚柔性机械臂振动抑制的LQ最优控制方法[J].振动与冲击,1999,18(1):49-52.
[11]WangJD, LeeTL, JuangYT. New Methods to Design an Integral Variable Structure Controller [J]. IEEE Trans on Automatic Control, 1996, 41 (1) ,140-143.
[12]Lin J, Lewis F L. Two--time Scale Fuzzy Logic Controller of Flexible Link Robot Arm[J]. Fuzzy Sets and Systems, 2003, 139(1): 125-149.
[13]Kokotovic P V, Khalil H K, Reilly J O. Singular Perturbation Methods in Control: Analysis and Design[M]. Inc. Orlando: Academic Press, 1986.
[14]郭益深[1],陈力[1].漂浮基柔性空间机械臂基于Backstepping控制策略设计的姿态、关节运动控制[J].工程力学,2009(10):165-170.
[15]张友安 [1],吕凤琳 [2],孙富春 [3].基于奇异摄动的双连杆柔性臂模糊控制[J].计算机仿真,2004,21(4):109-112.
[16]楼顺天胡昌华.基于MATLAB的系统分析与设计-模糊系统[M].西安：西安电子科技大学出版社,2001.
[17]诸静等著.模糊控制原理与应用[M].北京:机械工业出版社,1995:841.